Suchergebnisse

Ten lots of pork loin, packed in cans, were inoculated with approximately 106Clostridium botulinum spores per can. Each lot was seeded with a different strain; five type A and five type B strains were used. The pack comprised 5,690 cans, including controls, and contained about 109 spores per dose. The cans were irradiated with Co60 in the range of 0 to 5.0 Mrad (0.5 Mrad increments) at 5 to 25 C, incubated for 6 months at 30 C, and examined for swelling, toxicity, and recoverable C. botulinum. The minimal experimental sterilizing dose (ESD) based on nonswollen, nontoxic, but nonsterile end points was 2.5 < ESD ≤ 3.0 Mrad, and based on non-spoiled sterile cans was 3.5 < ESD ≤ 4.0 Mrad. The theoretical minimal radiation dose (MRD), the 12D equivalent, varied with the method of computation: 4.74, 4.33 ± 0.17, and 4.19 to 4.99 Mrad were obtained by the Weibull, Spearman-K̈arber, and Schmidt-Nank techniques, respectively. Calculation of D and MRD values by the conventional Schmidt-Nank method produced increasing values with rising dosage; this finding was compared with the data derived by the other two methods of calculation. Suggestions for estimating the MRD of a prototype radiation process are offered.

Ten lots of diced cured ham, packed in cans, were inoculated with approximately 106Clostridium botulinum spores per can. Each lot was seeded with a different strain (five type A and five type B strains). All cans were irradiated to various dose levels with Co60. Evidence provided by swelling, toxicity, and recoverable C. botulinum with 6,350 cans demonstrated that: (i) 4.5 Mrad was more than adequate as a sterilization dose; (ii) the minimal experimental sterilizing dose (ESD) based on nonswollen nontoxic endpoints was 2.0 < ESD ≤ 2.5 Mrad, and based on non-spoiled sterile cans was 3.0 < ESD ≤ 3.5 Mrad (the latter was supported by the computed theoretical 12D dose); (iii) D values calculated from botulinal survival data indicated that, as a group, the type A strains were more radioresistant than type B strains; strains 12885A and 41B, with respective D values of 0.242 and 0.175, represented the most resistant of each type; (iv) swollen cans did not always contain toxin, nor were toxic cans always swollen; (v) viable C. botulinum can exist for 6 months at 30 C without producing visible or toxic spoilage at doses of 3.0 Mrad and lower, including, in some instances, 0.0 Mrad; and (vi) a phenomenon similar to heat activation of spores occurred at sublethal radiation doses.